Tom,
You mentioned that you "had to cut and expand pipes on each of the
installs." What type of tool is used to expand the pipes
inexpensively at home?
Thanks,
Matt
At 08:50 PM 1/6/2008, Tom Rightler wrote:
Jim,
The Flowmaster or Pypes systems really aren't all that hard to
install in your garage. I've done several exhaust systems in a day
taking my time and making sure everything fits as it should.
I put a system on a 72 Monte Carlo with stock manifolds that
consisted of a set of down pipes (from Pypes) that made up the
length difference from the stock manifold to where a typical header
would dump out at, then finished it off with one of those cheap
Summit Racing systems. It went OK at best, the generic Summit kit
was not my choice, but the owner of the car wanting to get it done cheaply.
I put the Flowmaster American Thunder system with the 40 series
mufflers on my 70 back in 2000. It does fit the car nice, no
complaints there, just the mufflers rotted out on the bottom and
blew the baffles loose so I need to replace them. That was a system
off a set of Dynomax Headers.
I put the Pypes 2.5" X Crossover system on the Charger. It was one
of the best fitting systems I've ever put on a car...seriously. The
only problem I ran into with it are where the Hooker Super Comp
headers dumped out under the body. They didn't line up with the
humps in the trans crossmember so I had to be a little creative
there and use a mandrel bent pipe to complete the system. I used
their Race Flo Mufflers that came with the system. Overall, the
mufflers sound OK at best, and the car doesn't have that MOPAR sound
like it should. I'm considering changing the mufflers out.
On my 86 Cutlass that I put a 350 in and full length headers, I used
a Dynomax dual system designed for G body cars with small block
chevy engines. The system fit OK. I don't like how they get around
the fact that G body trans crossmembers don't have 2 humps in them
for dual exhaust. They bend the pipe around and then try to tuck up
back up. That system has been on that car since 2001 and it's
rotting and falling apart, probably in part to the fact I was
driving the car thourgh those wonderful NJ winters for a couple
years until I got the truck. I would imagine the system they have
for 68-72 A body GM would be a tad better in quality.
All of these systems can be installed in 1 day by yourself and as
long as you have certain tools like a pipe cutter or sawzall and
some wrenches. I've had to cut and expand pipes on each of the
installs I listed above.
Tom Rightler
MCC Newsletter Editor
----- Original Message ----- From: "J. Brady" <[EMAIL PROTECTED]>
To: "The Chevelle Mailing List" <chevelle-list@chevelles.net>
Sent: Sunday, January 06, 2008 10:36 AM
Subject: Re: [Chevelle-list] best self-install kit?
That's one thing about my current system that's
probably working out as a "good" thing- since it's not
sealed real well right now, all the moisture drains
out on the floor in my garage!! 8^]
I appreciate everyone' input on this, thanks so much.
I saw the Pypes setup in either my Jegs or Summit
catalog, and knew nada about their stuff, so it's good
to hear some feedback on it.
And I guess you guys are concluding from me talking
about an exhaust swap, that I decided NOT to trade the
car 8^] The exhaust thing has been the biggest
thing bumming me out about the vehicle, so if I can
get that resolved I think I'll be in a much better
place.
Regards,
Jim
--- John Nasta <[EMAIL PROTECTED]> wrote:
OTOH, I've had Flowmasters on my 69 El Camino for
about 4 years, and
it is a driver that I park on the street and drive
in all kinds of
weather, and everything is fine. No signs of rust or
rot anywhere.
Maybe just the fact that I drive it more often keeps
the water from
sitting in there long enough to do damage. Leaving a
car sitting (esp.
in this kind of weather) is probably bad for just
about any muffler.
Just throwing out an alternative experience. Your
results may vary.
John
Quoting Tom Rightler <[EMAIL PROTECTED]>:
> The Flowmaster kit was easy to install on my 70,
however, after 6
> years and less than 20K miles, the mufflers blew
out on the bottom
> from moisture collecting and now they need to be
replaced. The
> pipes themselves are not in that great of shape
either and this is
> on a car that doesn't go out in the rain.
____________________________________________________________________________________
Looking for last minute shopping deals?
Find them fast with Yahoo! Search.
http://tools.search.yahoo.com/newsearch/category.php?category=shopping
--
No virus found in this incoming message.
Checked by AVG Free Edition.
Version: 7.5.516 / Virus Database: 269.17.13/1211 - Release Date:
1/6/2008 11:57 AM