That is what I like about the BC-2000 telemetry module that you can install on the eltek/valre modular rectifiers. Scheduled or manual load testing and graphing over the network. You never have to leave your chair to test all of your batts.
From: Lewis Bergman Sent: Friday, January 5, 2018 11:00 AM To: af@afmug.com Subject: Re: [AFMUG] Sealed or flooded batteries for DC backup? AGM still needs an annual check if you want your sites to stay up. We started a maintenance routine after we got caught with our pants down. We load tested them once every year and always ended up replacing 4 or 5 across all the sites. Maybe 50 or so sites or roughly 100 batteries. So maybe a failure rate of around 5%. Maybe I was just buying crappy AGM but they weren't cheap. On Fri, Jan 5, 2018 at 10:20 AM Christopher Tyler <ch...@totalhighspeed.net> wrote: On a side note, most AGM batteries are also DOT approved (at least the Northstar brand is), so you can "legally" carry them in your vehicle without worrying about hazmat. -- Christopher Tyler MTCRE/MTCNA/MTCTCE/MTCWE Total Highspeed Internet Services 417.851.1107 ----- Original Message ----- From: ch...@wbmfg.com To: af@afmug.com Sent: Friday, January 5, 2018 10:16:31 AM Subject: Re: [AFMUG] Sealed or flooded batteries for DC backup? AGM are great, unless you are cheap... From: Jeremy Sent: Friday, January 5, 2018 9:07 AM To: af@afmug.com Subject: Re: [AFMUG] Sealed or flooded batteries for DC backup? Gave up flooded years ago. Had a few sites where the APC exploded the batteries. Even when that didn't happen, I got tired of the yearly battery check and fill at all the sites. When I started my own company I switched to AGM and never looked back. They are amazing. Also, we don't use APCs anymore except at a couple of large sites where we use the 3000XL, which has a much better charging system. On Fri, Jan 5, 2018 at 6:38 AM, David M <dmilho...@wletc.com> wrote: there is always an evaporation issue with flooded.. They have to be maintained on a regular schedule in order to have extended life beyond 5 yrs AGM/GEL expensive but reliable with little maintenance. Give em a good home and little venting and get 7 to 10 with those. On 1/4/2018 3:47 PM, Robert Andrews wrote: Sounds like a problem with the Charge controller being incorrectly set. If this is on-grid, I would lower the voltage the charge controller is maintaining and make sure it is set to NOT do any equalize cycles. Then flooded should be better. Of course if the environment is causing evaporation that is a different problem. I didn't find telecom batteries were worth the expense. So if I dumped wet, I would probably go with sealed Marine.. Best, Robert On 01/04/2018 01:38 PM, TJ Trout wrote: I have been really liking flooded batteries over the last 10 years or so because I am able to service the battery and extend the life but I am finding that on sites that I forget to add distilled water at least twice a year sometimes the batteries dry out due to the charge controller over gassing the batteries. Right now I'm trying to decide between Walmart deep Cycles, rack mount telecom batteries or just sealed RV Marine deep cycle batteries. What is the best bang-for-the-buck currently considering the life span and capacity ? Thanks TJ