Dimitri's car has a working York ac compressor which complicates the job and doubles the time...
-Curt From: Curly McLain via Mercedes <mercedes@okiebenz.com> To: Mercedes Discussion List <mercedes@okiebenz.com> Sent: Tuesday, February 10, 2015 8:53 PM Subject: Re: [MBZ] Overheating 240D update >I replaced the short leaky hose under the thermostat housing today >as I suspect it was causing an air bubble possibly leading to the >overheating problem. >Wow what an ordeal! It took most of the day to replace that hose! >Time will tell if this solves the problem. In the meantime, the >starter motor has bit the dust. Prior to a cold start, I have to >whack the solenoid for it to engage. > >Sent from my iPhone >__________________ Its not that bad, but it helps to have the official MB hose, and the gasket for the thermostat housing to the block. (Or I used to seal it up again with whatever was left of the gasket and permatex blue silicon.) Never had one leak after... The trick is to start the hose on the WP, then slide in the the thermo housing, start it on that then shove it together. Soap on the inside of the hose, or WD40 helps too. I don't think it ever took me more than an hour including putting the radiator hose back on and clamping everything down. I could do it in a lot less than that if it was a contest. _______________________________________ http://www.okiebenz.com To search list archives http://www.okiebenz.com/archive/ To Unsubscribe or change delivery options go to: http://mail.okiebenz.com/mailman/listinfo/mercedes_okiebenz.com All posts are the result of individual contributors and as such, those individuals are responsible for the content of the post. The list owner has no control over the content of the messages of each contributor. _______________________________________ http://www.okiebenz.com To search list archives http://www.okiebenz.com/archive/ To Unsubscribe or change delivery options go to: http://mail.okiebenz.com/mailman/listinfo/mercedes_okiebenz.com All posts are the result of individual contributors and as such, those individuals are responsible for the content of the post. The list owner has no control over the content of the messages of each contributor.